This information is intended for use by health professionals
BuTrans 5 microgram/hour, transdermal patch.
BuTrans 10 microgram/hour, transdermal patch.
BuTrans 20 microgram/hour, transdermal patch.
Each 5 microgram/hour transdermal patch contains 5 mg of buprenorphine in a 6.25 cm2 area releasing a nominal 5 micrograms of buprenorphine per hour over a period of 7 days.
Each 10 microgram/hour transdermal patch contains 10 mg of buprenorphine in a 12.5 cm2 area releasing a nominal 10 micrograms of buprenorphine per hour over a period of 7 days.
Each 20 microgram/hour transdermal patch contains 20 mg of buprenorphine in a 25 cm2 area releasing a nominal 20 micrograms of buprenorphine per hour over a period of 7 days.
For the full list of excipients, see section 6.1.
BuTrans 5 microgram/hour is a square, beige coloured patch with rounded corners marked BuTrans 5 μg/h.
BuTrans 10 microgram/hour is a rectangular, beige coloured patch with rounded corners marked BuTrans 10 μg/h.
BuTrans 20 microgram/hour is a square, beige coloured patch with rounded corners marked BuTrans 20 μg/h.
Treatment of non-malignant pain of moderate intensity when an opioid is necessary for obtaining adequate analgesia.
BuTrans is not suitable for the treatment of acute pain.
BuTrans is indicated in adults.
BuTrans should be administered every 7th day.
Patients aged 18 years and over
The lowest BuTrans dose (BuTrans 5 microgram/hour transdermal patch) should be used as the initial dose. Consideration should be given to the previous opioid history of the patient (see section 4.5) as well as to the current general condition and medical status of the patient.
During initiation of treatment with BuTrans, short-acting supplemental analgesics may be required (see section 4.5) as needed until analgesic efficacy with BuTrans is attained.
During the titration process, the dose may be adjusted every 3-days (72 hours). Thereafter, the 7-day dosing interval should be maintained. Subsequent dosage increases may then be titrated based on the need for supplemental pain relief and the patient's analgesic response to the patch.
To increase the dose, a larger patch should replace the patch that is currently being worn, or a combination of patches should be applied in different places to achieve the desired dose. It is recommended that no more than two patches are applied at the same time, up to a maximum total dose of 40 microgram/hour BuTrans. A new patch should not be applied to the same skin site for the subsequent 3-4 weeks (see section 5.2). Patients should be carefully and regularly monitored to assess the optimum dose and duration of treatment.
In the absence of adequate pain control, the possibility of hyperalgesia, tolerance and progression of underlying disease should be considered (see section 4.4). A BuTrans dose reduction or discontinuation of BuTrans treatment or treatment review may be indicated.
Conversion from opioids
BuTrans can be used as an alternative to treatment with other opioids. Such patients should be started on the lowest available dose (BuTrans 5 microgram/hour transdermal patch) and continue taking short-acting supplemental analgesics (see section 4.5) during titration, as required.
The safety and efficacy of BuTrans in children below 18 years of age has not been established. No data are available.
No dosage adjustment of BuTrans is required in elderly patients.
No special dose adjustment of BuTrans is necessary in patients with renal impairment.
There is no need for dosage adjustment of BuTrans in patients with mild to moderate hepatic impairment.
Buprenorphine is metabolised in the liver. The intensity and duration of its action may be affected in patients with impaired liver function. Therefore, such patients should be carefully monitored during treatment with BuTrans.
Patients with severe hepatic impairment may accumulate buprenorphine during BuTrans treatment. Consideration of alternate therapy should be considered, and BuTrans should be used with caution, if at all, in such patients.
Method of administration
Route of administration
Transdermal patch to be worn for 7 days. The patch must not be divided or cut into pieces.
In order to ensure effective analgesia of buprenorphine and to minimise the potential of skin reactions (see section 4.4), the following directions of use should be followed:
BuTrans should be applied to non-irritated, intact skin of the upper outer arm, upper chest, upper back or the side of the chest, but not to any parts of the skin with large scars. BuTrans should be applied to a relatively hairless or nearly hairless skin site. If none are available, the hair at the site should be cut with scissors, not shaven.
If the application site must be cleaned, it should be done with clean water only. Soaps, alcohol, oils, lotions or abrasive devices must not be used. The skin must be dry before the patch is applied. BuTrans should be applied immediately after removal from the sealed sachet. Following removal of the protective layer, the transdermal patch should be pressed firmly in place with the palm of the hand for approximately 30 seconds, making sure the contact is complete, especially around the edges. If the edges of the patch begin to peel off, the edges may be taped down with suitable skin tape to ensure a 7 day period of wear. The patch should be worn continuously for 7 days. Bathing, showering, or swimming should not affect the patch. If a patch falls off, a new one should be applied and worn for 7 days.
Duration of administration
BuTrans should under no circumstances be administered for longer than absolutely necessary. If long-term pain treatment with BuTrans is necessary in view of the nature and severity of the illness, then careful and regular monitoring should be carried out (if necessary with breaks in treatment) to establish whether and to what extent further treatment is necessary.
After removal of the patch, buprenorphine serum concentrations decrease gradually and thus the analgesic effect is maintained for a certain amount of time. This should be considered when therapy with BuTrans is to be followed by other opioids. As a general rule, a subsequent opioid should not be administered within 24 hours after removal of the patch. At present, only limited information is available on the starting dose of other opioids administered after discontinuation of the transdermal patch (see section 4.5).
Patients with fever or exposed to external heat
While wearing the patch, patients should be advised to avoid exposing the application site to external heat sources, such as heating pads, electric blankets, hot water bottles, heat lamps, sauna, hot tubs, and heated water beds, etc, as an increase in absorption of buprenorphine may occur. When treating febrile patients, one should be aware that fever may also increase absorption resulting in increased plasma concentrations of buprenorphine and thereby increased risk of opioid reactions.
BuTrans is contraindicated in:
• patients with known hypersensitivity to the active substance buprenorphine or to any of the excipients (see section 6.1),
• opioid dependent patients and for narcotic withdrawal treatment,
• conditions in which the respiratory centre and function are severely impaired or may become so,
• patients who are receiving MAO inhibitors or have taken them within the last two weeks (see section 4.5),
• patients suffering from myasthenia gravis,
• patients suffering from delirium tremens.
BuTrans should be used with particular caution in patients with:
• Respiratory depression
• CNS depressants co-administration (see below and section 4.5)
• Serotonergic agents (see below and section 4.5)
• Psychological dependence [addiction], abuse profile and history of substance and/or alcohol abuse (see below)
• Sleep apnoea
• Acute alcohol intoxication
• Head injury, intracranial lesions or increased intracranial pressure, shock, a reduced level of consciousness of uncertain origin
• Severely impaired hepatic function (see section 4.2)
Significant respiratory depression has been associated with buprenorphine, particularly by the intravenous route. A number of overdose deaths have occurred when addicts have intravenously abused buprenorphine, usually with benzodiazepines concomitantly. Additional overdose deaths due to ethanol and benzodiazepines in combination with buprenorphine have been reported. (see Section 4.9). Caution should be exercised when prescribing BuTrans to patients known to have, or suspected of having, problems with drug or alcohol abuse or serious mental illness.
Concomitant use of opioids such as buprenorphine and sedative medicines such as benzodiazepines or related drugs may result in sedation, respiratory depression, coma and death. Because of these risks, concomitant prescribing with these sedative medicines should be reserved for patients for whom alternative treatment options are not possible. If a decision is made to prescribe buprenorphine concomitantly with sedative medicines, the lowest effective dose should be used, and the duration of treatment should be as short as possible.
The patients should be followed closely for signs and symptoms of respiratory depression and sedation. In this respect, it is strongly recommended to inform patients and their caregivers to be aware of these symptoms (see section 4.5).
Concomitant administration of BuTrans and other serotonergic agents, such as MAO inhibitors, selective serotonin re-uptake inhibitors (SSRIs), serotonin norepinephrine re-uptake inhibitors (SNRIs) or tricyclic antidepressants may result in serotonin syndrome, a potentially life-threatening condition (see section 4.5). If concomitant treatment with other serotonergic agents is clinically warranted, careful observation of the patient is advised, particularly during treatment initiation and dose increases.
Symptoms of serotonin syndrome may include mental-status changes, autonomic instability, neuromuscular abnormalities, and/or gastrointestinal symptoms.
If serotonin syndrome is suspected, a dose reduction or discontinuation of therapy should be considered depending on the severity of the symptoms.
Buprenorphine is a µ-opioid agonist, acting as a full agonist with respect to analgesia and as a partial agonist with respect to its respiratory depressant properties (see section 5.1).
Long-term treatment effects and tolerance
In all patients, tolerance to the analgesic effects, hyperalgesia, physical dependence, and psychological dependence may develop upon repeated administration of opioids, whereas incomplete tolerance is developed for some side effects like opioid induced constipation. Particularly in patients with chronic non cancer pain, it has been reported that they may not experience a meaningful amelioration in pain intensity from continuous opioid treatment in the long term. It is recommended to re-evaluate the appropriateness of continued use of BuTrans regularly at the time of prescription renewals in patients. When it is decided that there is no benefit for continuation, gradual down titration should be applied to address withdrawal symptoms.
Opioid use disorder (abuse and dependence)
Repeated use of BuTrans may lead to Opioid use disorder (OUD). Abuse or intentional misuse of BuTrans may result in overdose and/or death. The risk of developing OUD is increased in patients with a personal or a family history (parents or siblings) of substance use disorders (including alcohol use disorder), in current tobacco users or in patients with a personal history of other mental health disorders (eg major depression, anxiety and personality disorders). Patients treated with opioid medications should be monitored for signs of OUD, such as drugseeking behaviour (eg too early requests for refills), particularly with patients at increased risk. This includes the review of concomitant opioids and psycho-active drugs (like benzodiazepines). For patients with signs and symptoms of OUD, consultation with an addiction specialist should be considered. If opioid discontinuation is to occur see section 4.4 Long-term treatment effects and tolerance.
A withdrawal syndrome may occur upon abrupt cessation of therapy. Withdrawal (abstinence syndrome), when it occurs, is generally mild, begins after 2 days and may last up to 2 weeks. Withdrawal symptoms include agitation, anxiety, nervousness, insomnia, hyperkinesia, tremor and gastrointestinal disorders. When a patient no longer requires therapy with buprenorphine, it may be advisable to taper the dose gradually to prevent symptoms of withdrawal. Administration of buprenorphine to persons who are physically dependent on full µ-opioid agonists may precipitate an abstinence syndrome depending on the level of physical dependence, and the timing and dose of buprenorphine.
Sleep-related breathing disorders
Opioids can cause sleep-related breathing disorders including central sleep apnoea (CSA) and sleep-related hypoxemia. Opioid use increases the risk of CSA in a dose-dependent fashion. In patients who present with CSA, consider decreasing the total opioid dosage.
Skin reactions at application site
To minimise the risk of occurrence of application site skin reactions, it is important to follow the posology instructions (see section 4.2).
Application site reactions with BuTrans are usually presented by a mild or moderate skin inflammation (contact dermatitis), and their typical appearance may include erythema, oedema, pruritus, rash, small blisters (vesicles), and painful/burning sensation at the application site. Most commonly the cause is skin irritation (irritant contact dermatitis), and these reactions resolve spontaneously after BuTrans removal.
Patients and caregivers should be instructed accordingly to monitor the application sites for such reactions. If allergic contact dermatitis is suspected, relevant diagnostic procedures should be performed to determine if sensitisation has occurred and its actual cause (buprenorphine and/or other ingredients of the patch).
Since CYP3A4 inhibitors may increase concentrations of buprenorphine (see section 4.5), patients already treated with CYP3A4 inhibitors should have their dose of BuTrans carefully titrated since a reduced dosage might be sufficient in these patients.
BuTrans is not recommended for analgesia in the immediate post-operative period or in other situations characterised by a narrow therapeutic index or a rapidly varying analgesic requirement.
Buprenorphine may lower the seizure threshold in patients with a history of seizure disorder.
Severe febrile illness may increase the rate of buprenorphine absorption from BuTrans transdermal patches.
In humans limited euphorigenic effects have been observed with buprenorphine. This may result in some abuse of the product.
Opioids may influence the hypothalamic-pituitary-adrenal or –gonadal axes. Some changes that can be seen include an increase in serum prolactin, and decreases in plasma cortisol and testosterone. Clinical symptoms may be manifest from these hormonal changes.
BuTrans should not be used at higher doses than recommended.
Effect of other active substances on the pharmacokinetics of buprenorphine
Buprenorphine is primarily metabolised by glucuronidation and to a lesser extent (about 30%) by CYP3A4. Concomitant treatment with CYP3A4 inhibitors may lead to elevated plasma concentrations with intensified efficacy of buprenorphine.
Studies with the CYP3A4 inhibitor ketoconazole did not produce clinically relevant increases in mean maximum (Cmax) or total (AUC) buprenorphine exposure following BuTrans with ketoconazole as compared to BuTrans alone.
The interaction between buprenorphine and CYP3A4 enzyme inducers has not been studied. Co-administration of BuTrans and enzyme inducers (e.g. phenobarbital, carbamazepine, phenytoin and rifampicin) could lead to increased clearance which might result in reduced efficacy.
Reductions in hepatic blood flow induced by some general anaesthetics (e.g. halothane) and other medicinal products may result in a decreased rate of hepatic elimination of buprenorphine.
BuTrans must not be used concomitantly with MAOIs or in patients who have received MAOIs within the previous two weeks (see section 4.3).
BuTrans should be used cautiously when co-administered with:
Serotonergic medicinal products, such as MAO inhibitors, selective serotonin re-uptake inhibitors (SSRIs), serotonin norepinephrine re-uptake inhibitors (SNRIs) or tricyclic antidepressants as the risk of serotonin syndrome, a potentially life-threatening condition, is increased (see section 4.4).
Other central nervous system depressants: other opioid derivatives (analgesics and antitussives containing e.g. morphine, dextropropoxyphene, codeine, dextromethorphan or noscapine). Certain antidepressants, sedative H1-receptor antagonists, alcohol, anxiolytics, neuroleptics, clonidine and related substances. These combinations increase the CNS depressant activity.
Sedative medicines such as benzodiazepines or related drugs as concomitant use increases the risk of sedation, respiratory depression, coma and death because of additive CNS depressant effect. The dose and duration of concomitant use should be limited (see section 4.4). Such agents include sedatives or hypnotics, general anesthetics, other opioid analgesics, phenothiazines, centrally acting anti-emetics, benzodiazepines and alcohol.
At typical analgesic doses buprenorphine is described to function as a pure mu receptor agonist. In BuTrans clinical studies subjects receiving full mu agonist opioids (up to 90 mg oral morphine or oral morphine equivalents per day) were transferred to BuTrans. There were no reports of abstinence syndrome or opioid withdrawal during conversion from entry opioid to BuTrans (see section 4.4).
There are no or limited amounts of data from the use of BuTrans in pregnant women. Studies in animals have shown reproductive toxicity (see section 5.3). The potential risk for humans is unknown.
Buprenorphine crosses the placenta and buprenorphine and the active metabolite norbuprenorphine can be detected in newborn serum, urine and meconium following in utero exposure.
Towards the end of pregnancy high doses of buprenorphine may induce respiratory depression in the neonate even after a short period of administration. Prolonged use of buprenorphine during pregnancy can result in neonatal opioid withdrawal syndrome. Therefore, BuTrans should not be used during pregnancy and in women of childbearing potential who are not using effective contraception unless the potential benefit justifies the potential risk to the foetus.
Buprenorphine is excreted in human milk. Studies in rats have shown that buprenorphine may inhibit lactation. Available pharmacodynamic/toxicological data in animals has shown excretion of buprenorphine in milk (see section 5.3). A risk to the newborn/infants cannot be excluded. BuTrans should be used with caution during breast-feeding.
No human data on the effect of buprenorphine on fertility are available. In a fertility and early embryonic development study, no effects on reproductive parameters were observed in male or female rats (see section 5.3).
BuTrans has a major influence on the ability to drive and use machines. Even when used according to instructions, BuTrans may affect the patient's reactions to such an extent that road safety and the ability to operate machinery may be impaired. This applies particularly in the beginning of treatment and in conjunction with other centrally acting substances including alcohol, tranquillisers, sedatives and hypnotics. An individual recommendation should be given by the physician. A general restriction is not necessary in cases where a stable dose is used.
Patients who are affected and experience side effects (e.g. dizziness, drowsiness, blurred vision) during treatment initiation or titration to a higher dose should not drive or use machines for at least 24 hours after the patch has been removed.
This medicine can impair cognitive function and can affect a patient's ability to drive safely. This class of medicine is in the list of drugs included in regulations under 5a of the Road Traffic Act 1988. When prescribing this medicine, patients should be told:
• The medicine is likely to affect your ability to drive.
• Do not drive until you know how the medicine affects you.
• It is an offence to drive while you have this medicine in your body over a specified limit unless you have a defence (called the 'statutory defence').
• This defence applies when:
o The medicine has been prescribed to treat a medical or dental problem; and
o You have taken it according to the instructions given by the prescriber and in the information provided with the medicine.
• Please note that it is still an offence to drive if you are unfit because of the medicine (i.e. your ability to drive is being affected).
Details regarding a new driving offence concerning driving after drugs have been taken in the UK may be found here: https://www.gov.uk/drug-driving-law
Serious adverse reactions that may be associated with BuTrans therapy in clinical use are similar to those observed with other opioid analgesics, including respiratory depression (especially when used with other CNS depressants) and hypotension (see section 4.4).
The following undesirable effects have occurred:
Very common (≥1/10), common (≥1/100, <1/10), uncommon (≥1/1000, <1/100), rare (≥1/10,000, <1/1000),
very rare (<1/10,000), not known (cannot be estimated from the available data).
System organ class
Very common (≥1/10)
Common (≥1/100, <1/10)
Uncommon (≥1/1000, <1/100)
Rare (≥1/10,000, <1/1000)
Very rare (<1/10,000)
Not known (cannot be estimated from the available data)
Immune system disorders
Metabolic and nutritional disorders
Drug dependence (see Section 4.4)
Nervous system disorders
Disturbance in attention
Involuntary muscle contractions
Sleep apnoea syndrome
Ear and labyrinth disorders
Respiratory, thoracic and mediastinal disorders
Skin and subcutaneous tissue disorders
Application skin discolouration
Musculoskeletal and connective tissue disorders
Renal and urinary disorders
Reproductive system and breast disorders
General disorders and administration site conditions
Application site reactions1*
Drug withdrawal syndrome
Influenza like illness
Drug withdrawal syndrome neonatal
Alanine aminotransferase increased
Injury, poisoning and procedural complications
1 Includes common signs and symptoms of contact dermatitis (irritative or allergic): erythema, oedema, pruritus, rash, vesicles, painful/burning sensation at the application site.
* In some cases delayed local allergic reactions (allergic contact dermatitis) occurred with marked signs of inflammation. Mechanical injuries during patch removal (e.g. laceration) are also possible in patients with fragile skin. Chronic inflammation may lead to long-lasting sequelae, such as post inflammatory hyper- and hypopigmentation, as well as dry and thick scaly skin lesions, which may closely resemble scars. In such cases treatment with BuTrans should be terminated (see sections 4.3 and 4.4).
Buprenorphine has a low risk of physical dependence. After discontinuation of BuTrans, withdrawal symptoms are unlikely. This may be due to the very slow dissociation of buprenorphine from the opioid receptors and to the gradual decrease of buprenorphine plasma concentrations (usually over a period of 30 hours after removal of the last patch). However, after long-term use of BuTrans, withdrawal symptoms similar to those occurring during opioid withdrawal, cannot be entirely excluded. These symptoms include agitation, anxiety, nervousness, insomnia, hyperkinesia, tremor and gastrointestinal disorders.
Reporting of suspected adverse reactions
Reporting suspected adverse reactions after authorisation of the medicinal product is important. It allows continued monitoring of the benefit/risk balance of the medicinal product. Healthcare professionals are asked to report any suspected adverse reactions via the Yellow Card Scheme at: www.mhra.gov.uk/yellowcard or search for MHRA Yellow Card in the Google Play or Apple App Store.
Symptoms similar to those of other centrally acting analgesics are to be expected. These may include respiratory depression, including apnoea, sedation, drowsiness, nausea, vomiting, cardiovascular collapse and marked miosis.
Remove any patches from the patient's skin.
Establish and maintain a patent airway, assist or control respiration as indicated and maintain adequate body temperature and fluid balance. Oxygen, intravenous fluids, vasopressors and other supportive measures should be employed as indicated.
A specific opioid antagonist such as naloxone may reverse the effects of buprenorphine, although naloxone may be less effective in reversing the effects of buprenorphine than other µ-opioid agonists. Treatment with continuous intravenous naloxone should begin with the usual doses but high doses may be required.
Pharmacotherapeutic group: Analgesics, opioids; ATC code: N02 AE01
Buprenorphine is a μ-opioid agonist, acting as a full agonist with respect to analgesia and as a partial agonist with respect to its respiratory depressant properties. It also has antagonistic activity at the kappa opioid receptor.
Other pharmacologic effects
In vitro and animal studies indicate various effects of natural opioids, such as morphine, on components of the immune system; the clinical significance of these findings is unknown. Whether buprenorphine, a semisynthetic opioid, has immunological effects similar to morphine is unknown.
Like other opioid analgesics, buprenorphine has a potential risk of respiratory depression. However, evidence suggests that buprenorphine is a partial agonist with respect to its respiratory depressant activity and a ceiling effect has been reported following intravenous doses of greater than 2 μg/kg. Respiratory depression appears to be a rare occurrence at therapeutic doses of the transdermal preparation [up to 40 μg/h].
Efficacy has been demonstrated in seven pivotal phase III studies of up to 12 weeks duration in patients with non-malignant pain of various aetiologies. These included patients with moderate and severe OA and back pain. BuTrans demonstrated clinically significant reductions in pain scores (approximately 3 points on the BS-11 scale) and significantly greater pain control compared with placebo.
A long term, open-label extension study (n=384) has also been performed in patients with non-malignant pain. With chronic dosing, 63% of patients were maintained in pain control for 6 months, 39% of patients for 12 months, 13% of patients for 18 months and 6% for 21 months. Approximately 17% were stabilised on the 5 mg dose, 35% on the 10 mg dose and 48% on the 20 mg dose.
There is evidence of enterohepatic recirculation.
Studies in non-pregnant and pregnant rats have shown that buprenorphine passes the blood-brain and placental barriers. Concentrations in the brain (which contained only unchanged buprenorphine) after parenteral administration were 2-3 times higher than after oral administration. After intramuscular or oral administration buprenorphine apparently accumulates in the foetal gastrointestinal lumen – presumably due to biliary excretion, as enterohepatic circulation has not fully developed.
Each patch provides a steady delivery of buprenorphine for up to seven days. Steady state is achieved during the first application. After removal of BuTrans, buprenorphine concentrations decline, decreasing approximately 50% in 12 hours (range 10–24 h).
Following BuTrans application, buprenorphine diffuses from the patch through the skin. In clinical pharmacology studies, the median time for BuTrans 10 microgram/hour to deliver detectable buprenorphine concentrations (25 picograms/ml) was approximately 17 hours. Analysis of residual buprenorphine in patches after 7-day use shows 15% of the original load delivered. A study of bioavailability, relative to intravenous administration, confirms that this amount is systemically absorbed. Buprenorphine concentrations remain relatively constant during the 7-day patch application.
A study in healthy subjects demonstrated that the pharmacokinetic profile of buprenorphine delivered by BuTrans is similar when applied to upper outer arm, upper chest, upper back or the side of the chest (midaxillary line, 5th intercostal space). The absorption varies to some extent depending on the application site and the exposure is at the most approximately 26% higher when applied to the upper back compared to the side of the chest.
In a study of healthy subjects receiving BuTrans repeatedly to the same site, an almost doubled exposure was seen with a 14 day rest period. For this reason, rotation of application sites is recommended, and a new patch should not be applied to the same skin site for 3-4 weeks.
In a study of healthy subjects, application of a heating pad directly on the transdermal patch caused a transient 26-55% increase in blood concentrations of buprenorphine. Concentrations returned to normal within 5 hours after the heat was removed. For this reason, applying direct heat sources such as hot water bottles, heat pads or electric blankets directly to the patch is not recommended. A heating pad applied to a BuTrans site immediately after patch removal did not alter absorption from the skin depot
Buprenorphine is approximately 96% bound to plasma proteins.
Studies of intravenous buprenorphine have shown a large volume of distribution, implying extensive distribution of buprenorphine. In a study of intravenous buprenorphine in healthy subjects, the volume of distribution at steady state was 430 l, reflecting the large volume of distribution and lipophilicity of the active substance.
Following intravenous administration, buprenorphine and its metabolites are secreted into bile, and within several minutes, distributed into the cerebrospinal fluid. Buprenorphine concentrations in the cerebrospinal fluid appear to be approximately 15% to 25% of concurrent plasma concentrations.
Biotransformation and elimination
Buprenorphine metabolism in the skin following BuTrans application is negligible. Following transdermal application, buprenorphine is eliminated via hepatic metabolism, with subsequent biliary excretion and renal excretion of soluble metabolites. Hepatic metabolism, through CYP3A4 and UGT1A1/1A3 enzymes, results in two primary metabolites, norbuprenorphine and buprenorphine 3-O-glucuronide, respectively.
Norbuprenorphine is glucuronidated before elimination. Buprenorphine is also eliminated in the faeces. In a study in post-operative patients, the total elimination of buprenorphine was shown to be approximately 55 l/h.
Norbuprenorphine is the only known active metabolite of buprenorphine.
Effect of buprenorphine on the pharmacokinetics of other active substances
Based on in vitro studies in human microsomes and hepatocytes, buprenorphine does not have the potential to inhibit metabolism catalysed by the CYP450 enzymes CYP1A2, CYP2A6 and CYP3A4 at concentrations obtained with use of BuTrans 20 µg/h transdermal patch. The effect on metabolism catalysed by CYP2C8, CYP2C9 and CYP2C19 has not been studied.
Reproductive and developmental toxicity
No effect on fertility or general reproductive performance was observed in rats treated with buprenorphine.
In embryofoetal developmental toxicity studies conducted in rats and rabbits using buprenorphine, no embryofoetal toxicity effects were observed. In a rat pre- and post-natal developmental toxicity study with buprenorphine there was pup mortality, decreased pup body weight and concomitant maternal reduced food consumption and clinical signs.
A standard battery of genotoxicity tests indicated that buprenorphine is non-genotoxic.
In long-term studies in rats and mice there was no evidence of any carcinogenic potential relevant for humans.
Systemic toxicity and dermal toxicity
In single- and repeat-dose toxicity studies in rats, rabbits, guinea pigs, dogs and minipigs, BuTrans caused minimal or no adverse systemic events, whereas skin irritation was observed in all species examined.
Toxicological data available did not indicate a sensitising potential of the additives of the transdermal patches.
Adhesive matrix (containing buprenorphine):
[(Z)-octadec-9-en-1-yl] (Oleyl oleate),
4-oxopentanic acid, (Levulinic Acid)
Poly[acrylic acid-co-butylacrylate-co-(2-ethylhexyl)acrylate-co-vinylacetate] (5:15:75:5), cross-linked (DuroTak 387-2054)
Adhesive matrix (without buprenorphine):
Poly[acrylic acid-co-butylacrylate-co-(2-ethylhexyl) acrylate-co-vinylacetate] (5:15:75:5), not cross-linked (DuroTak 387-2051).
Separating foil between the adhesive matrices with and without buprenorphine: Poly(Ethyleneterephthalate) – foil.
Poly(Ethyleneterephthalate) – tissue.
Release liner (on the front covering the adhesive matrix containing buprenorphine) (to be removed before applying the patch):
Poly(Ethyleneterephthalate) – foil, siliconised, coated on one side with aluminium.
Do not store above 25°C.
Sealed child resistant sachet, composed of identical top and bottom layers of heat-sealable laminate, comprising (from outside to inside) paper, PET, polyethylene-based copolymer, aluminium and poly(acrylic acid-co-ethylene).
Pack Sizes: 1, 2, 3, 4, 5, 8, 10 and 12 transdermal patches.
Not all pack sizes may be marketed.
The patch should not be used if the seal is broken.
Disposal after use:
When changing the patch, the used patch should be removed, the adhesive layer folded inwards on itself, and the patch disposed of safely and out of sight and reach of children.
Napp Pharmaceuticals Limited
Cambridge Science Park
Date of first authorisation 10/06/2005
Date of last renewal 27/11/2008
22 November 2021